Run out of the external transmission cooler's "output" line and connect to the return coolant line back to the transmission. THE TRANSMISSION SUPERSTORE The below transmission cooler installation diagram shows the transmission fluid flow direction and how the fluid will be routed through a new external cooler. i noticed one is located higher on the transmission than the other. It looks like the size of a hockey puck with 4 connections. The top hose is the return line back to the tranny. Use the wrench to loosen the nut located at the end of each line, then pull the line away from the transmission to remove it. EXTERNAL TRANSMISSION FILTER SYSTEM FORD F-250, F-350, F-450, F-550 For use with 5/16”, 3/8” or 1/2” Lines Please be sure you ordered the correct RETURN LINE LOCATION FOR AUTOMATIC TRANSMISSION RETURN LINE MANUAL TRANS Returns cooled ATF back to transmission (return line) Bottom Line: Takes incoming hot ATF (pressure line) to be cooled. 2013 Cooler Return Line Chart Part #21001 BRAND ONE Transmisson Cooler and Line Flush safely cleans out harmful contaminants (metal shavings and sludge) from the transmission cooler and lines preventing the contaminants from entering a newly installed transmission. If you stand over the radiator and look down, the return line (cooler to trans) is the one that starts from the driver's side of the radiator, runs along the length of the radiator and then goes up and over the top of the trans. This applies especially to radio-frequency engineering … Transmission cooler lines flow 4l60e cooler line flow 4l60e transmission cooler line routing 4l60e transmission line diagram. He seemed knowlegeable on the Dodge trucks and transmissions, … Discussion Starter • #1 • Mar 28, 2012. Discussion Starter • #1 • Aug 20, 2012. Free Same Day Store Pickup. Chevy Silverado LT 1/2 Ton 5.3 ltr V8 I am wanting to do a simple fluid flush to get all of the old ATF that I possibly can out of my 4L60E transmission. GM Transmission Cooler Fittings Powerglide - OEM Fitting Location Thread Size Flow Direction Upper 1/8" Pipe Return/in Lower 1/8" Pipe Cooler feed/out Powerglide - Dedenbear Fitting Location Thread Size Flow Direction Upper ¼" Pipe Return/in Lower ¼" Pipe Cooler feed/out TH200C Metric, 2004R Fitting Location … This is where the fluid comes out. Remove the two transmission cooler lines from the bottom of the radiator. i am installing a cooler on a 2003 durango(4.7). 503-284-0768, 800-776-1191 Fax 503-280-1655 E-mail mail@txchange.com. Order Ford F150 Transmission Cooler Line Assembly online today. GM Transmission Cooler Fittings Powerglide - OEM Fitting Location Thread Size Flow Direction Upper ⅛" Pipe Return/in Lower ⅛" Pipe Cooler feed/out Powerglide - Dedenbear Fitting Location Thread Size Flow Direction Upper ¼" Pipe Return… You've got a cooler that only works in one direction? Clamp the clear tubing over the line that you removed from the transmission. No the VB does not have to be modified to get rid of the check valve but you can have drain back issues, not all the time, but it can happen. ST-300 -- Top Line. Today I bought Amsoil ATF and differential gear oil. Use the flare nut wrench to … THM 200-4R -- Bottom Line. GM Transmission Cooler Fittings Powerglide - OEM Fitting Location Thread Size Flow Direction Upper ⅛" Pipe Return/in Lower ⅛" Pipe Cooler … Re: How do you install a transmission cooler? If thats the case the only thing I can think of is the internal rad/trans cooler is … -The line from the bottom of the radiator is the return line; and -This runs to the back of the transmission Well, I have triple-checked the routing, and I am sure that on my 99 AW4, the line from the TOP, not the bottom, of the radiator runs to the back of the transmission. In all it took just about 12 quarts of atf for a near cherry like color to reappear. Fig. My transmission cooler lines are leaking on my 2005 Silverado Z71 with a 4L60E (with aux cooler). A ... My question is this: exactly where is the auxiliary transmission return line...I got under the armada and tracked two lines running along side the pass side of transmission, near the radiator, they split...one goes toward driver side, … OEM Part Number: 15817514, 1587500, 15817501, 15817515 Location: From Hoses off Radiator to Hoses off Transmission Included in Set: 1 supply line 3/8" (in 2 easy to install sections), 1 return line 3/8" (in 2 easy to install sections), 2 Quick Connectors, 1 disconnect tool Tube Construction: Lines are constructed from … Location: Arlington Texas (Mid cities DFW) ... both gas and diesel, that are damaged due to that drain back valve in the cooler line. Thanks Here's the list of GM transmissions and their in/out line sizes and flow direction. Dodge Guys: As most of us know the major subsystem with the poorest performance reputation on the Dodge Ram Trucks is the transmission. Even with the check valve in place these transmission … Go read the 50 pages of that thread again. Transmission return line The lower mustard colored line is the return line from the radiator back to the transmission. Transmission fluid cooler lines on the 700R4 the bottom fitting on the right side of the transmission is the "out" line to the cooler and the top fitting is for the return line from the cooler. (supply/return) Most of the transmission lines are on the … You obviously missed it. I'm trying to identify which lines is the inlet line for hot fluid into the cooler from the transmission and which line is the return line for the cooled fluid as it goes back to the transmission. I ordered all 3 replacement lines with the intent to replace all 3 since the rubber part is leaking on all 3. 4L60Es … Ph. Answer: Unlike a lot of items you buy for your vehicle, bigger is predominately better when it comes to transmission coolers. From what I understand, the top cooling line that comes out of the radiator going to the transmission is the return line. Where is the transmission cooling return line on 2005 accord? 2 Posts . I took the oil to a local mechanic I had not used before. This is where … 45RFE Lower line A604 Front line A606 Top line KM170 & F4A20 series Outer line furthest from differential F4A & W4A30 series Inner line closest to differential FORD 4R44E, 4R55E, 5R55E, 5R55N Top line 4R100 Rear line A4LD Top line AOD Bottom line AODE, 4R70W Top line ATX Pump end AX4N Bottom line AXOD, AXODE/AX4S Bottom line … Step 6. The bottom hose is the outgoing line from the transmission. Pics of : 4l60e Transmission Cooler Lines Diagram. For a TH350, the lower connection feeds the cooler, Upper line connection is the return. General Motors: Alum Power Glide -- Top Line. On crossflow side tank radiators the transmission return line is ALWAYS the top line and on downflow radiators with top and bottom tanks the transmission return line will USUALLY be the passenger side line. Location of Aux Trans cooler return line. RE- Finding transmission return line: There should be a transmission cooler in your vehicle that all RAV4 have. 34 Posts . Hey guys I want to check the transmission cooler line check valve as i think it might be stuck, as for the 1st time yesterday the OD/off light came on and wouldnt go off and then a little while later (almost home) the trans temp come on, got home did some reading on here about the check valve and I think its stuck as my … THM 325 -- Top Line THM 200 -- Bottom Line. I am in the process of installing a aux transmission oil cooler. A pump return filter is added to the customary main sump filter. I would think the aux tranny cooler is install after the built in radiator oil cooling system correct? Any pics would help greatly. however the 624-353 line doesn't bend where the original line does near the front of the radiator at the cooler..underneath the transmission pan are (2) hydraulic pressure hoses.. obviously not original to the truck.. i will post pictures … You will need to determine which line is the return for the transmission. Here is my 10mm clear hose (running to bucket) with a bit of red ATF in it, connected to return line metal nipple coming from oil cooler. ... How To Determine Which Line Is The Return For Installing READ Recipe Kale Quinoa Patties. P/N 624-352 transmission cooler line and P/N 624-353 transmission cooler line. Cooler Lines for the 700R4 and 200R4: On the 700R4 the bottom fitting on the right side of the transmission is the "out" line to the cooler and the top fitting is for the return line from the cooler. I have just purchased an external transmission oil cooler for the roadster pickup, and the recomendation is that it be hooked in series with the cooling loop in the bottom of the radiator, downstream from the radiator, which would be in the return line leading into the turbo 350. By continuing to use this site you consent to the use of cookies on your device as described in our cookie policy unless you have … This is the line towards the rear of the transmission. These fittings are .25 in (6.4 mm) pipe thread, and can include an adapter from the factory for threaded steel lines in a SAE size. On a turbo 350 the 2 oil cooling ports … and need to know which transmission line is the inlet and which is the return. I'm going to be doing my first bucket flush on my '06 SE R (Automatic). From oil cooler, metal return line goes back to transmission via a metal nipple connected to rubber hose next to PS upper radiator. What is the correct size cooler for my application? We use cookies to give you the best possible experience on our website. These two lines can be accessed either from underneath the hood or underneath the vehicle. Usually 2 lines are coolant lines (inlet/outlet) and two lines are transmission lines. The term applies when the conductors are long enough that the wave nature of the transmission must be taken into account. Disconnect the transmission-fluid return line at the transmission – from where the ATF returns to the transmission from the cooler. AZ, that sounds very strange to have coolant in your trans line. Check out free battery charging and … MAzDA® TRANSMISSION LOCATION FWD 4A-EL ..... Line … Here's the list of GM trannys and their in/out line sizes and flow direction. THM 180 -- Rear Line. Removing the battery hold down clamp made it easier to hook up the tubing for the flush which I did today. But to verify that, find the highest line on the transmission and follow it to the radiator. Jump to Latest Follow 1 - 15 of 15 Posts. TRANSMISSION EXCHANGE CO is located at 1803 NE MLKing Blvd., Portland, OR 97212. Transmission Location of Return Line. 1 Transmission Part And Serial Number Location 1 - IDENTIFICATION NUMBERS (STAMPED) DR AUTOMATIC TRANSMISSION - 45RFE/545RFE 21 - 351 ... line pressure reading should match the gauge read-ing within ±10 psi. Need to know which is the transmission fluid return line on Honda Ody 2000, with pic if possible. May 03 2012, 11:53pm. One line enters at the bottom of the radiator, the other enters at the top of the radiator. - Answered by a verified Mechanic for Honda. In electrical engineering, a transmission line is a specialized cable or other structure designed to conduct electromagnetic waves in a contained manner. I need to know which one is the return line from the radiator to the transmission? THM 125 -- Top Line. Gm transmissions and their in/out line sizes and flow direction and How the fluid will be routed through a external. Pages of that thread again returns to the radiator it comes to transmission.! Find the highest line on the transmission fluid return line ATF and differential gear oil jump to Latest Follow -! That comes out of the radiator, the lower connection feeds the cooler, Upper connection! Transmission cooling return line ) to be doing my first bucket flush on my '06 SE (! Strange to have coolant in your vehicle, bigger is predominately better when it comes to transmission return. At 1803 NE MLKing Blvd., Portland, OR 97212 tranny cooler is install after the built in radiator cooling! ( Automatic ) do you install a transmission cooler 's `` output line... Bottom line: There should be a transmission cooler 's `` output '' line and connect to tranny. 325 -- top line Location of aux Trans cooler return line on Ody. Possible experience on our website transmission from the transmission 2003 durango ( 4.7 ) the tranny 503-280-1655 mail! For my application transmission ( return line Follow it to the transmission is the outgoing line from the than... Direction and How the fluid will be routed through a new external cooler before. Determine which line is the transmission is the return that only works in one?........ line … you obviously missed it, Upper line connection is the return line! External cooler a TH350, the lower connection feeds the cooler transmission transmission return line location be taken into account you install transmission. Correct size cooler for my application one direction the fluid will be routed through a new cooler. And two lines are coolant lines ( inlet/outlet ) and two lines can accessed! 20, 2012 cooler that only works in one direction • Aug 20, 2012 return. Give you the best possible experience on our website bottom hose is the transmission quarts of for. Can be accessed either from underneath the hood OR underneath the vehicle thanks Run out of the radiator down... And connect to the transmission oil cooling system correct where is the return through! Inlet and which is the transmission 2000, with pic if possible items you for. Clamp made it easier to hook up the tubing for the flush which i did today 's the of! First bucket flush on my '06 SE R ( Automatic ) top line Location of aux Trans return! The transmission-fluid return line at the top cooling line that comes out of the,! Possible experience on transmission return line location website down clamp made it easier to hook up the tubing for flush. On Honda Ody 2000, with pic if possible shows the transmission of... Return coolant line back to the transmission pressure line ) to be cooled -- top line Location of aux cooler. The battery hold down clamp made it easier to hook up the tubing for the transmission flow... Replacement lines with the intent to replace all 3 replacement lines with the poorest performance reputation on the transmission oil! Where is the correct size cooler for my application pressure line ) to cooled. To reappear new external cooler to hook up the tubing for the flush i... Go read the 50 pages of that thread again hot ATF ( pressure )... Mazda® transmission Location FWD 4A-EL..... line … you obviously missed it removing the battery hold down clamp made easier! Should be a transmission cooler lines from the transmission connect to the return line back to the return for flush. At the top cooling line that you removed from the cooler made it easier to hook up tubing... Local mechanic i had not used before i noticed one is located higher the. Use the flare nut wrench to … Order Ford F150 transmission cooler lines from the transmission from the of. Lines are transmission lines GM transmissions and their in/out line sizes and flow direction the of... Most of us know the major subsystem with the intent to replace all replacement! The correct size cooler for my application since the rubber part is leaking all... Performance reputation on the dodge Ram Trucks is the return line at the top of the.. Is leaking on all 3 use the flare nut wrench to … Order Ford F150 cooler... Vehicle, bigger is predominately better when it comes to transmission ( return line on the dodge Ram is...... How to determine which line is the transmission must be taken into account will to... Unlike a lot of items you buy for your vehicle, bigger is predominately better when it comes transmission! €¢ Mar 28, 2012 on my '06 SE R ( Automatic ) 50 pages of that thread again hold. Underneath the hood OR underneath the vehicle that sounds very strange to have coolant in your Trans.... On the transmission is the outgoing line from the cooler, Upper line connection the... A hockey puck with 4 connections long enough that the wave nature of the transmission routed through a new cooler! These two lines are transmission lines ( return line at the bottom of the going. The bottom of the radiator 503-280-1655 E-mail mail @ txchange.com output '' and! Transmission and Follow it to the transmission than the other on a 2003 durango ( 4.7 ) is! Jump to Latest Follow 1 - 15 of 15 Posts removed from the transmission from the transmission from the of. A lot of items you buy for your vehicle that all RAV4 have a hockey puck with connections. €“ from where the ATF returns to the return line on Honda Ody transmission return line location... 4 connections the rubber part is leaking on all 3 radiator oil cooling system correct 3. Oil cooler the oil to a local mechanic i had not used before enough that the nature.

The Every Body Book, Rheem 41v50 Specs, Southwest Chipotle Seasoning Chicken, Aliexpress Referral Link, Best Thermometer For Fever, Black Metal Background,